Scope of Work: Remove existing shingles and install new shingle roof on Nature Station, located at Land Between The Lakes, in Trigg County, KY. The single story building is approximately 40-feet wide by 105-feet long, with a 4/12 pitch roof. Two 29-feet wide 4/12-pitch roots tie into the 105-feet long ridge on the front side of the building. The roof measures approximately 5000 square feet. A large brick chimney, three powered roof exhausts, and several sewer vents are present. Remove the existing 3 layers of roofing, felt paper, and all rotted or damaged decking material. Assume 200 square feet of 3/4-inch CDX plywood of new roof decking. Remove three existing powered roof exhausts and repair holes. Provide new chimney step flashing and sewer vent flashing. Contractor shall use 15lb. felt paper moisture barrier beneath shingles. Install metal roof drip edge around entire perimeter of roof deck. Submittals: 1. Roof shingles shall be 30-year guarantee dimensional type. Color by owner. 2. Roof drip edge shall be metal 18 gauge, or heavier. Brown in color. 3. Flashing shall be 16-ounce copper, or 16-gauge aluminum. 4. Ridge vent shall be ABS plastic, shingle over type, with insect screen and rain baffle. Black in color. Additional Requirements: Field verify existing conditions and all measurements. The three layers of existing shingles have been tested. The middle layer of roofing shingles test results show they contain approximately 20% asbestos. The building will be occupied during this project. Coordinate hours of operation and placement of equipment with Forest Service representative prior to commencement of work. The contractor shall not leave the roof open or unprotected from rain or weather. The roof shall be kep weather tight daily. All roofing and flashing material shall be removed at the front of building and loaded into dumpster or truck with minimal spillage and damage to gutters, landscaping, and adjacent structures and buildings. Cover and protect foliage where necessary to achieve this result. A general site pick up shall be performed daily. Contractor shall be a licensed roofing contractor with qualification for removal and disposal of asbestos type shingles, and shall carry all applicable insurances. Contractor must comply with all applicable OSHA, state, environmental, local codes and regulations, and manufacturer's instructions. The package is expected to be released on or around January 16, 2002. To request a copy of this solicitation please send your request via email to
[email protected] and include the following information: Company Name, Point of Contact, Street Address, Telephone Number, and Email Address. Russell Hayes (270) 924-2026) will serve as the Technical Point of Contact for this contract.